Determination of plasticity following deformation and welding of austenitic stainless steel

Intergranular strain has been associated with high-temperature cracking of welded pipework in 316H austenitic stainless steel material used in nuclear power plant heat exchangers. In this study, neutron diffraction has been used to study the development of intergranular strains in plastically-deformed and welded 316H stainless steel. Measurements have been made of the intergranular strain evolution with increasing plastic strain in base material, and correlated with further measurements made in samples extracted from welded pipes, where the pipes were welded following plastic deformation to different levels of plastic strain. Strong tensile strain evolution was seen on the compliant 200 grain family. The results were correlated with various proxy measures of plastic strain, including hardness and diffraction peak width, and excellent agreement was obtained

Effect of prior cold work on the mechanical properties of weldments

Heat exchanger units used in steam raising power plant are often manufactured using many metres of austenitic stainless steel tubes that have been plastically formed (bent and swaged) and welded into complex shapes. The amount of plastic deformation (pre-straining) before welding varies greatly. This has a significant effect on the mechanical properties of the welded tubes and on the final residual stress state after welding. The aim of the present work was to measure and understand the combined effects of pre-straining and welding on the properties and residual stress levels in stainless steel tubing weldments. Effects of plastic deformation were simulated by plastically straining three identical stainless steel tubes to different strain levels (0%, 10% and 20%). Then each tube was cut into two halves and welding back together. The variation in mechanical properties across weldments was measured using digital image correlation (DIC) and a series of strain gauges (SG). Residual stresses were measured on the 0% (undeformed) and 20% prestrained and welded tubes by neutron diffraction. It was found that the welding process had a marked effect on the tensile properties of parent material within 25mm of the weld centre-line. Evidence of cyclic strain hardening was observed in the tube that had not been pre-strained, and evidence of softening seen in the 10% and 20% pre-strained tubes. Macroscopic residual stresses were measured to be near zero at distances greater than 25 mm from the weld centre-line, but measurements in the 20% pre-strained tube revealed the presence of micro residual stresses having a magnitude of up to 50 MPa

Effect of industrial wastewater ontotal protein and the peroxidase activity in plants

The aim of this study is to investigate the effects of industrial wastewaters on protein and the peroxidase activity in Lycopersicon esculentum Mill., Capsicum annuum L., Phaseolus vulgaris L. and Vicia faba L. Industrial wastewaters were taken from Dardanel Fisheries Company, Tekel alcoholicdrinks companies’ wastewater treatment plants and from one station which is located in the middle of the Sarýçay River. Wastewaters were applied to 6 weeks old plants with directly irrigation water. Physiological changes in the plants were observed by the means of measuring the protein and enzyme activity. The largest increase in protein was observed as 190.9 and 136.3% in V. faba treated with Sarýçay River water and Tekel wastewater, respectively. In P. vulgaris which was treated with Dardanelwastewater, the total protein amount increased by 84% compared to control plants. After the wastewater treatment, the peroxidase activity decreased in all plants. The largest peroxidase decrease was 80% in L. esculentum treated with Tekel wastewater. In P. vulgaris, peroxidase decreased by 59 and 51% when treated with Dardanel wastewater and Sarýçay River water, respectively. It was concluded that the increase in total protein amount and the decrease in peroxidase activity demonstrated theindustrial wastewater’s blocking effects on plants defense systems

New realization of Chua's circuit and verification of chaos by harmonic balance analysis

Chua's circuit, which consists of two capacitors, one inductor, two resistors, one linear voltage-controlled voltage source (VCVS) and voltage-controlled current source (VCCS) type non-linear element has been realized by operational amplifiers. Various dynamical phenomena such as periodic orbit with periods T, 2T, and 4T, single scroll and double scroll similar to the Lorenz attractor have been observed experimentally by changing only the resistance value of the linear resistor R6. The experimental observations have been confirmed by computer simulations and also using harmonic balance analysis

Implementation of a simplified method for actuation of ferrofluids

This paper was presented at the 3rd Micro and Nano Flows Conference (MNF2011), which was held at the Makedonia Palace Hotel, Thessaloniki in Greece. The conference was organised by Brunel University and supported by the Italian Union of Thermofluiddynamics, Aristotle University of Thessaloniki, University of Thessaly, IPEM, the Process Intensification Network, the Institution of Mechanical Engineers, the Heat Transfer Society, HEXAG - the Heat Exchange Action Group, and the Energy Institute.Magnetic actuation of ferrofluids is an emergent field that will open up new possibilities in various fields of engineering. The quality and topology of the magnetic field that is being utilized in such systems is determinant in terms of flow properties, flow rates and overall efficiency. Determining the optimal magnetic field topology to achieve the desired results, and determining the methods by which these magnetic fields are to be generated are central problems of obtaining the desired flow. A healthy comparison of various magnetic field topologies requires a varied set of examples from the most simplified to most sophisticated. Such comparisons are necessary to have a well grounded starting point. This study focuses on a particular pump design that employs a simplified magnetic field topology to obtain ferrofluid flow. The results of this paper such as flow and pressure difference are intended to form a baseline for future reference.Sabancı University Internal Research Grant, no: IACF09-0064

Electrodialytic processes in solid matrices. New insights into batteries recycling. A review.

Electrodialytic Remediation has been widely applied to the recovery of different contaminants from numerous solid matrices solving emerging issues of environmental concern. Results and conclusions reported in studies about real contaminated matrices are summarizes in this work. The influence of the pH value on the treatment effectiveness has been widely proved highlighting the phenomenon “water splitting” in the membrane surface. This dissociation of water molecules is related to the “limiting current” which is desirable to be exceed at the Anion Exchange Membrane in order to produce the entering of protons toward solid matrix. Other important parameters for the optimization of the technique, such as the current density and the liquid to solid ratio, are also discussed through the revision of studies using real solid matrices. This work also focusses on the pioneer proposal of electrokinetic technologies for the recycling of lithium ion batteries considering the relevance of waste properties in the design and optimization of the technique. From a thorough literature revision, it could be concluded that further experimental results are needed to allow an optimal application of the technique to the rising problem of residues from batteries. The main aim of this work is to take the first steps in the recovery of valuable metals from spent batteries, such as Li and Co, incorporating principles of green chemistry.The authors acknowledge the financial support from the “Plan Propio de Investigación de la Universidad de Málaga with Project numbers: PPIT.UMA.B1.2017/20 and PPIT.UMA.B5.2018/17 and the European project THROUGH H2020-MSCA-RISE- 2017-778045. The first author also acknowledge the postdoctoral contract obtained from University of Malaga

Current clinician perspective on non-vitamin K antagonist oral anticoagulant use in challenging clinical cases.

OBJECTIVE: The evolution of non-vitamin K antagonist anticoagulants (NOACs) has changed the horizon of stroke prevention in atrial fibrillation (SPAF). All 4 NOACs have been tested against dose-adjusted warfarin in well-designed, pivotal, phase III, randomized, controlled trials (RCTs) and were approved by regulatory authorities for an SPAF indication. However, as traditional RCTs, these trials have important weaknesses, largely related to their complex structure and patient participation, which was limited by strict inclusion and extensive exclusion criteria. In the real world, however, clinicians are often faced with complex, multimorbid patients who are underrepresented in these RCTs. This article is based on a meeting report authored by 12 scientists studying atrial fibrillation (AF) in diverse ways who discussed the management of challenging AF cases that are underrepresented in pivotal NOAC trials. METHODS: An advisory board panel was convened to confer on management strategies for challenging AF cases. The article is derived from a summary of case presentations and the collaborative discussions at the meeting. CONCLUSION: This expert consensus of cardiologists aimed to define management strategies for challenging cases with patients who underrepresented in pivotal trials using case examples from their routine practice. Although strong evidence is lacking, exploratory subgroup analysis of phase III pivotal trials partially informs the management of these patients. Clinical trials with higher external validity are needed to clarify areas of uncertainty. The lack of clear evidence about complex AF cases has pushed clinicians to manage patients based on clinical experience, including rare situations of off-label prescriptions

Modelling human factors in perceptual multimedia quality: On the role of personality and culture

Perception of multimedia quality is shaped by a rich interplay between system, context, and human factors. While system and context factors are widely researched, few studies in this area consider human factors as sources of systematic variance. This paper presents an analysis on the influence of personality (Five-Factor Model) and cultural traits (Hofstede Model) on the perception of multimedia quality. A set of 144 video sequences (from 12 short movie excerpts) were rated by 114 participants from a cross-cultural population, producing 1232 ratings. On this data, three models are compared: a baseline model that only considers system factors; an extended model that includes personality and culture as human factors; and an optimistic model in which each participant is modeled as a random effect. An analysis shows that personality and cultural traits represent 9.3% of the variance attributable to human factors while human factors overall predict an equal or higher proportion of variance compared to system factors. In addition, the quality-enjoyment correlation varied across the movie excerpts. This suggests that human factors play an important role in perceptual multimedia quality, but further research to explore moderation effects and a broader range of human factors is warranted